Artillery: Sending Smart Mortars Into The Hills

Archives

February 14, 2011: The U.S. Army is pressuring a supplier to speed up the delivery of GPS guided, 120mm mortar shells. Afghanistan is a place where 120mm mortars are very useful, and a GPS guided 120mm mortar shell is seen as very helpful for avoiding civilian casualties and reducing the amount of ammo you have to truck in. The troops have become used to GPS guided ammunition, and the 120mm mortar has just enough explosives to take out most targets, if the shell is GPS guided.

It was only a year ago, after over a decade of searching (and procrastinating), that the U.S. Army finally decided to choose a GPS guided 120mm mortar shell from one of three suppliers (two American and one Israeli). All the systems were similar. The winner was one of the American systems, the RCGM (Roll-Controlled Guided Mortar). This one works by using a special fuze that includes a GPS unit and little wings that move to put the 120mm mortar shell closer to the target. Thus all you need do to convert existing 120mm mortar shells to RCGM is the RCGM fuzes (which handle the usual fuze functions, as in setting off the explosives in the shell, in addition to the guidance functions.) The RCGM equipped shells cost about $7,000 each. The army wants them delivered this year, the sooner the better.

To use RCGM, you place the fuse into a device that loads the target GPS coordinates, then screw the fuze into the shell, and fire the shell. It would also be possible to program each fuze once it is screwed into the shell, via a metal probe that would go into a hole in the fuze, transfer the data, and signal that that the transfer was accurately made.

As a result of adopting the RCGM, guided 120mm shells just got a lot cheaper and easier to use. This is particularly crucial for 120mm mortars, which are used by units close to the front lines, where not a lot of ammo can be carried, and resupply is riskier since the enemy is so close. Thus a guided 120mm shell means fewer shells getting fired to get the job done. Every U.S. infantry battalion is equipped with 120mm mortars.

RCGM is not the first attempt to produce a guided 120mm mortar round. There are several, so the army can afford to put the three best candidates through a round of competitive tests. It’s about time, because the army has been working on a guided 120mm mortar shell for a long time. Four years ago, the U.S. sent XM395 laser guided 120mm mortar rounds to Iraq and Afghanistan for testing. The XM395 Precision Guided Mortar Munition had been in development for 13 years, and was almost cancelled at least once because of the delays. The 17.3 kg (38 pound) XM395 round has a range of 7.5 kilometers, and will land within a meter (three feet) of where the laser is pointed. The problem with laser guidance is that the enemy often hides somewhere the laser cannot reach (behind rocks or a building). GPS guided shells get around this problem.

Unguided mortar shells cannot put the first round as close as guided ones, and requires firing several rounds, and adjusting aim, before you get one on the target. Normally, an unguided 120mm shell will land anywhere within a 136 meter circle (on the first shot). The shells that did not come close enough often hurt nearby civilians, or even friendly troops. The GPS guided shell gets it right the first time. A guided mortar round is very useful in urban warfare, where a miss will often kill civilians. The 120mm mortar round has about 2.2 kg (five pounds) of explosives, compared to 6.6 kg (15) pounds in a 155mm shell. The smaller explosive charges limits collateral damage to civilians. While the laser guided round will land within a one meter circle, the GPS guided one lands within a ten meter (31 foot) circle. The GPS round is deemed the most useful, especially since the troops are satisfied with that degree of accuracy in GPS guided 155mm artillery shells, 227mm rockets and JDAM bombs.

 

X

ad

Help Keep Us From Drying Up

We need your help! Our subscription base has slowly been dwindling.

Each month we count on your contribute. You can support us in the following ways:

  1. Make sure you spread the word about us. Two ways to do that are to like us on Facebook and follow us on Twitter.
  2. Subscribe to our daily newsletter. We’ll send the news to your email box, and you don’t have to come to the site unless you want to read columns or see photos.
  3. You can contribute to the health of StrategyPage.
Subscribe   contribute   Close