Attrition: Germany Pays For Bad Decisions

Archives

September 11, 2015: Germany has responded to growing problems with key weapons by allocating $6.5 billion to fix serious problems with its Typhoon fighters (radar and needed upgrades), NH90 helicopters (the latest of many problems) and the army G36 assault rifle (needs to be replace). In addition to fixing these problems the military will receive larger stocks of spare parts so major systems (like ships, aircraft and armored vehicles) can be used intensively (whether it be peacekeeping, training or combat) without being shut down because there are not enough spares available. Some of these problems go back years and despite the new injection of cash the Defense Ministry admits that it will take up to eight years to apply this cash to fix all the problems the money is aimed at.  

These are all problems that have been around for a while. For example in 2009 the German Army conducted an evaluation of their new NH90 helicopters and found that for combat missions another model helicopter should be used whenever possible. A particular problem was the lack of ground clearance. The NH-90 could not land on a piece of ground with any obstacles higher than 16 cm (6.4 inches). That makes many battlefield landing zones problematic. That assumes you could even get on a NH90 and find a seat. The passenger seats could hold more than 110 kg (242 pounds). Combat equipment for German troops weighs 25 kg (55 pounds), meaning any soldier weighing more than 85 kg (187) has to take stuff off, put it on the floor, than quickly put it back on before exiting. Then there's the floor, it was not very sturdy and combat troops using the helicopter for a short while cause damage that takes the helicopter out of action for repairs. Worse, there is the rear ramp. It could not support troops carrying all their equipment, making it useless for rapid exits of combat troops. There was not enough room in the passenger compartment for door gunners. There were no strap downs for larger weapons, like portable rocket launchers or anti-aircraft missiles. The passenger compartment also did not allow for carrying cargo and passengers at the same time. The winch was not sturdy enough for commandoes to perform fast roping operations. And so on. Most of these problems have since been fixed, sort of, but the winch is still a problem. It’s so bad that only four of the 39 NH90s the army has are available for combat. Originally Germany ordered 122 NH90s at a cost of over $50 million each. Because of all the problems and continued cuts in the defense budget most of those on order were cancelled. The ten ton NH-90 can carry 21 troops or twelve casualties on stretchers, plus the crew of two. It first flew in 1995. The manufacturer is a consortium of French, German, Dutch and Italian firms, and has promised to fix all the problems. The Germans and Australians noted that, when it worked, the NH90 worked well. In 2010 Australia received eight of the 50 NH90 helicopters it ordered, and was not happy with the aircraft's performance. The overall complaint was poor reliability, design and durability. Many more spare parts have to be stocked than was originally planned. There have been long waits to get needed spares from the manufacturer (NHIndustries). Called the MRH90 in Australian service, the experience was similar to what the Germans encountered with their NH90s.

In 2015 the German army finally admitted that after years of user complaints and several rounds of testing, that there were indeed major accuracy and reliability problems with its G36 assault rifle. The G36 is a 3.3 kg (7.3 pound), 999mm (39 inch) long (758mm with stock folded) 5.56mm assault rifle. Effective range is 800 meters and it can use a 30 or 100 round magazine and was designed to be an improvement on the M16 design from the 1960s. On paper the G36 was a success, in combat it was not. This was particularly true in Afghanistan. While the G36 entered service in 1995 it didn’t get exposed to heavy combat use until 2008 and that’s when the complaints from the troops began. The German Army kept insisting there was no major problem but now agrees that a new assault rifle or a major overhaul of existing G36s is needed to make the rifle reliable enough for combat.

The Eurofighter Typhoon had fewer major problems but the Germans put off (for budget reasons) addressing many of the minor problems and manufacturer suggested upgrades. Now the Germans admit that the Typhoon requires more money to become a reliable and effective fighter-bomber.

 

 


Article Archive

Attrition: Current 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 2006 2005 2004 2003 2002 2001 2000 1999 


X

ad
0
20

Help Keep Us Soaring

We need your help! Our subscription base has slowly been dwindling. We need your help in reversing that trend. We would like to add 20 new subscribers this month.

Each month we count on your subscriptions or contributions. You can support us in the following ways:

  1. Make sure you spread the word about us. Two ways to do that are to like us on Facebook and follow us on Twitter.
  2. Subscribe to our daily newsletter. We’ll send the news to your email box, and you don’t have to come to the site unless you want to read columns or see photos.
  3. You can contribute to the health of StrategyPage. A contribution is not a donation that you can deduct at tax time, but a form of crowdfunding. We store none of your information when you contribute..
Subscribe   Contribute   Close